Important
General
liters in 3mm in mm in
kg lb kg lb rpm 1200150018001900kW 299345345345hp 407469469469with fan
kW 290330326
325890mm
hp 394449443441Nm 2380219618301734lbf ft 1755
1620
1350
1279
Nm lbf ft %m/s 6,37,99,510,0ft/sec 20,725,931,132,8MPa 2,342,161,801,71psi 339313261247MPa 15,215,715,715,1psi 2204
2277
2277
2190
kgm²(not including flywheel)lbft²kW 23334752hp
31
45
64
71
Compression ratio 17,1:1Bore 1315,16Stroke
1586,22This Technical Data Sheet and the corresponding Installation Instructions provide important information to ensure the installed engine will operate according to the design specification in the Volvo Penta application for certification.
Requirements marked with are considered as critical for exhaust emissions compliance according to the design specification in the Volvo Penta application for certification.
Failing to follow and meet these instructions and requirements when installing a certified engine in a piece of nonroad equipment for use in the United States violates U.S. federal law (40 CFR 1068.105(b)), subject to fines or other penalities as described in the Clean Air Act.
In-line four stroke diesel engine with direct injection. Rotation direction, counterclockwise viewed towards flywheel Number of cylinders 6Displacement, total 12,78780Firing order 1-5-3-6-2-4
3946Performance IFN Power
345 kW without fan Wet weight
Engine only (Estimated)(excl after treatment comp.)13252921Power pac
179023801755Torque at:
IFN Power辉腾suv
Max torque at engine speed
rpm
1200 rpm
Max combustion pressure at:
IFN Power
Total mass moment of inertia, J (mR 2)1,14327,1
Power tolerance ±2
Mean piston speed Effective mean pressure at:IFN Power Friction Power
Derating see Technical Diagrams
rpm 1200150019002200kW N/A
N/A
N/A
N/A
hp Nm lbf ft rpm rpm °C
°C °F °C °F °C °F liter/h liter US gal Max liter US gal Min
liter US gal h h °°°kPa psi
max °C °F 99%µ50%µEngine speed range for VCB activation:N/A Min engine speed with VCB still active:N/A Min oil temperature for VCB activation:N/A
Engine brake performance (only engines with VCB)Brake power:without fan Brake torque:
without fan
-13with manifold heater 3 kW and block heater
-30-22
*Specify oil and fuel quality
T>-15°C Oil VDS3 or VDS4 15W/40 T<-15°C Oil VDS3 or VDS4 5W/40 Cold start performance *Cold start limit temperature
without starting aid -155with manifold heater 3 kW
-2530°F
*See also general section in the sales guide Lubrication system
0,02Heater type Make
Power kW
Engaged hours (-30°C)
Cooling water temp engine block
Self circulating
哈雷重型机车
Volvo 21578298
2
12
-1°C Lubricating oil consumption (average)Oil system capacity including filters 369,51Oil pan capacity:(both variants)
307,93195,02Engine angularity limits:
front up 11front down 11side tilt
11
Oil change intervals/specifications VDS3
500VDS4
500Lubrication system
Lubrication oil temperature in sump:13026638Oil pressure at rated speed
300- 65044- 94
Oil filter filtration efficiency
(in accordance with ISO 4548-12)
14
liter/h US gal/h kPa psi Fuel supply line max. pressure, during engine stand still
kPa (meassured at fuel inlet connection)
psi
Fuel supply line min. pressure, during engine stand still
kPa (meassured at fuel inlet connection)
psi liter/h US gal/h kPa psi °C °F µ96%µ75%
µ
rpm 1200150018001900m³/min 19,023,02526cfm 671812883918
kPa
psi kW 229268269280BTU/min 13023152411529815923°C 544539493497°F
1011
1002
919
927
kPa 9121415125mm
psi 1,31,72,02,2m³/min 52,060,06263cfm
1836
2119
2190
2225
16523,9-125-18,1Fuel system
Fuel return line max. restriction
(measured at fuel return connection)202,9Max. allowable inlet fuel temp
(Measured at fuel inlet connection)60140System return flow at max. Speed 30,07,9System supply flow at max. Speed 13034,3Fuel supply line max. restriction (measured at fuel inlet connection)
304,4Intake and exhaust system Prefilter / Water separator micron size 10Governor type/make, standard Volvo/EMS2.3
Fuel filter filtration efficiency 4
6Charge air consumption at:(+25°C and 100kPa)
IFN Power
Fuel to conform to
Fuel corresponding to EN590:1999 or ASTM D
975-No or JIS KK2204:2004
Exhaust gas temperature after turbine at:
IFN Power
See front page for important information
Max allowable back pressure in exhaust line (after turbine)
50,7
Heat rejection to exhaust at:IFN Power See front page for important information
Max allowable air intake restriction including piping Pipe dimension Ø:Exhaust gas flow at:
(temp and pressure after turbine at the corresponding power setting)
IFN Power
rpm 1200150018001900kW 11,011,09,610,3BTU/min 626626546586kW 157177182214BTU/min 8928100661035012170
m²
foot²mm in kW 9,515,019,520,5hp 132027
28
liter US gal liter US gal
Coolant pump
drive/ratio l/s 3,74,75,76US gal/s 1,01,21,51,6l/s 3,24,25,55,5US gal/s 0,81,11,5
1,5
kPa
psi °C °F °C °F kPa
psi
kPa
psi
kPa
psi
°C
°F liter
US gal
Coolant
Yellow Volvo Coolant Solution (VCS)
Radiator cooling system type Closed circuit
Cooling system
Heat rejection radiation from engine at:IFN Power Heat rejection to coolant at:IFN Power
Fan diameter
890 mm
89035,04Standard radiator core area 0,88,61Fan drive ratio fan Ø8900,99:1 ccw
Fan power consumption 890 mm 6,3belt/1,41:1 cw
Coolant flow with standard system Coolant capacity:
engine
205,3std. 0,8m² radiator with hoses
24
180fully open
92198
Maximum static pressure head
(expansion tank height + pressure cap setting)10014,5Minimum coolant flow
Maximum outer circuit restriction incl. piping 65,09,4Thermostat:
华多利start to open 82Maximum top tank temperature 107225Recommended Draw down capacity.
The difference between min coolant level in the expansion tank and the lowest level where the engine's coolant system still are functioning
20,5
Minimum static pressure head
(expansion tank height + pressure cap setting)7010,2Standard pressure cap setting 7510,9
rpm 120015001800
1900kW
51606565BTU/min 2900341236963696kg/s 0,370,440,500,51°C 176180178177°F
349
356
352
351
suv 销量排行榜°C 42464950°F 108115120122
kPa psi kPa 211223217214psi 30,60
32,34
31,4731,04
m²foot²
0.8pull 890fan
rpm kW hp °C °F m 3/s ft 3/s Pa psi 1900
34555,6
132
9,3
沃尔沃328,4
0,99
469
Charge air mass flow
IFN Power Charge air inlet temp.
(Charge air temp after turbo compressor)IFN Power
Charge air cooler system
Heat rejection to charge air cooler IFN Power See front page for important information
Maximum pressure drop over charge air cooler incl. piping 121,74Charge air pressure (After charge air cooler)
郑州限号2021最新通知10月份See front page for important information Max allowable Charge air outlet temp.(Charge air temp after charge air cooler)
Engine speed Engine
power Air on temp Air flow
External restriction
Standard charge air cooler core area
0,88,61
Cooling performance:m² radiator and Cooling air flow and maximum additional external restriction at different radiator air temperatures based on 107°C TTT and 40% coolant. Valid at 1 atm.
发布评论